To correlate specific local immune responses with protection from corneal scarring, we examined immune cell infiltrates in the cornea after ocular challenge of vaccinated mice with herpes simplex virus type 1 (HSV-1). This is the first report to examine corneal infiltrates following ocular challenge of a vaccinated mouse rather than following infection of a naive mouse. Mice were vaccinated systemically with vaccines that following ocular challenge with HSV-1 resulted in (i) complete protection against corneal disease (KOS, an avirulent strain of HSV-1); (ii) partial protection, resulting in moderate corneal disease (baculovirus-expressed HSV-1 glycoprotein E [gE]); and (iii) no protection, resulting in severe corneal disease (mock vaccine). Infiltration into the cornea of CD4+ T cells, CD8+ T cells, macrophages, and cells containing various lymphokines was monitored on days 0, 1, 3, 7, and 10 postchallenge by immunocytochemistry of corneal sections. Prior to ocular challenge, no eye disease or corneal infiltrates were detected in any mice. KOS-vaccinated mice developed high HSV-1 neutralizing antibody titers (> 1:640) in serum. After ocular challenge, they were completely protected against death, developed no corneal disease, and had no detectable virus in their tear films at any time examined. In response to the ocular challenge, these mice developed high local levels of infiltrating CD4+ T cells and cells containing interleukin-2 (IL-2), IL-4, IL-6, or tumor necrosis factor alpha (TNF-alpha). In contrast, only low levels of infiltrating CD8+ T cells were found, and gamma interferon (IFN-gamma)-containing cells were not present until day 10. gE-vaccinated mice developed neutralizing antibody titers in serum almost as high as those of the KOS-vaccinated mice (> 1:320). After ocular challenge, they were also completely protected against death. However, the gE-vaccinated mice developed low levels of corneal disease and virus was detected in one-third of their eyes. Compared with KOS-vaccinated mice, the gE-vaccinated mice had a similar pattern of IFN-gamma, but a delay in the appearance of CD4+ T cells, CD8+ T cells, and IL-4-, IL-6-, and TNF-alpha-containing cells. In sharp contrast to those of the KOS-vaccinated mice, no cells containing IL-2 were detected in the eyes of gE-vaccinated mice at any time. Mock-vaccinated mice developed no detectable neutralizing antibody titer and were not protected from lethal HSV-1 challenge.(ABSTRACT TRUNCATED AT 400 WORDS)